« previous next »
Pages: [1]

Author Topic: *URGENT* help needed  (Read 2044 times)

Offline ajm-e30

  • Just got here
  • *
  • Posts: 4
*URGENT* help needed
« on: 02 September 2010, 18:34 »
hi all, ive got a bora tdi 130 that has a very confusing overheating issue, basically i can drive it for a while and sit in traffic and its fine but then when at a constant speed the temp will shoot up to 130ish, ive checked the w/pump which is new, its had a new stat and been pressure tested to the point it was left on for an hour and the cap has been pressure tested and both are fine, ive also flushed the cooling system too and all the people ive spoke to including vw cant figure it out, if ANY of you have any ideas then please let me no.

many thanks adam
Logged

Offline Ben Lessani

  • I live here
  • *****
  • Posts: 3,873
  • The poor mans MK2 Haynes author
Re: *URGENT* help needed
« Reply #1 on: 02 September 2010, 21:17 »
If it hit 130 - your HG is a goner.

Sounds more like your temp. sensor is reading wrong.
Logged

Offline ajm-e30

  • Just got here
  • *
  • Posts: 4
Re: *URGENT* help needed
« Reply #2 on: 02 September 2010, 22:12 »
temp sensor is new from vw
Logged

Offline Wayne

  • Sir Postalot
  • *
  • Posts: 32,051
Re: *URGENT* help needed
« Reply #3 on: 03 September 2010, 00:16 »
If it has got that hot, you have cooked it.
Logged

Offline danny_p

  • Forum addict
  • *
  • Posts: 4,646
Re: *URGENT* help needed
« Reply #4 on: 03 September 2010, 00:35 »
any idea what your oil temps are at ?

heater on full blast change things.

coolant contaminated with exhaust gasses ?

Logged
all the VW's have gone bar 1.

Offline ajm-e30

  • Just got here
  • *
  • Posts: 4
Re: *URGENT* help needed
« Reply #5 on: 03 September 2010, 08:12 »
Quote from: danny_p on 03 September 2010, 00:35
any idea what your oil temps are at ?

heater on full blast change things.

coolant contaminated with exhaust gasses ?



oil temp is good, heaters dont really change much until the air-con fan is on and ive done a block test on it and no gasses in the coolant, if it was HG then i would pressurise pretty much straight away as any hg failure does but this doesnt and like i say vw and my local specialist are having trouble working the issue out  :sad:
Logged

Offline tsr_adi

  • I live here
  • *****
  • Posts: 698
Re: *URGENT* help needed
« Reply #6 on: 03 September 2010, 10:05 »
could be faulty clocks?
Logged

Offline ajm-e30

  • Just got here
  • *
  • Posts: 4
Re: *URGENT* help needed
« Reply #7 on: 03 September 2010, 22:07 »
Quote from: tsr_adi on 03 September 2010, 10:05
could be faulty clocks?

is that a comon fault with the borat model??
Logged

Offline smartie78

  • Just got here
  • *
  • Posts: 6
Re: *URGENT* help needed
« Reply #8 on: 05 September 2010, 18:51 »
Quote from: ajm-e30 on 02 September 2010, 18:34
hi all, ive got a bora tdi 130 that has a very confusing overheating issue, basically i can drive it for a while and sit in traffic and its fine but then when at a constant speed the temp will shoot up to 130ish, ive checked the w/pump which is new, its had a new stat and been pressure tested to the point it was left on for an hour and the cap has been pressure tested and both are fine, ive also flushed the cooling system too and all the people ive spoke to including vw cant figure it out, if ANY of you have any ideas then please let me no.

many thanks adam
[/ check in measured value blocks in dash panel and engine ecu to check they both readin the same from coolant temp sensor.also checkradiator fan control switch on radiator for being faulty]
Logged
Pages: [1]
« previous next »